|
||||||||||||||||||||||||||||||||||||||||||||||||||||||||
Regulations BACK to VIRTUAL TOUR The following fact sheet was prepared by the ECAR Center staff. Once prepared, each ECAR Center fact sheet undergoes a review process with the applicable state environmental agency(ies). You can check on the status of the review process here. Please read the disclaimer on the status page. While we have tried to present a summary of the essential information on this topic, you should be aware that other items, such as local regulations, may apply to you. What You Need to Know Thirty years ago, something unexpected was discovered about the fluids used in air conditioners. Once they get into the air, they stay there a long time. Not much happens to them until they gradually diffuse several miles high, into the stratosphere. At that point, unshielded sunlight breaks them down. It turns out that they have a devastating effect on the ozone layer. A little bit of air conditioning fluid vapor destroys a lot of ozone, through a chain reaction. When that happens, the ultraviolet (burning) rays from the sun can reach the earth, a condition that greatly increases the risk that you and your kids will get skin cancer from being out in the sunshine. It's hard to believe that being sloppy with refrigerants can have that drastic an effect, but there is no longer any doubt. As a result, refrigerants are now tightly regulated. Refrigerant removal must be done with acceptable equipment, by certified technicians, and must be handled and recycled properly. The used filters from the operation must be treated as a hazardous waste. You also need to keep records. This fact sheet will outline the special rules that apply to refrigerant recovery and handling, and will give you links to more detailed information. Refrigerants (Freon, R-12, R-22, R-134a) are the chemicals used in vehicle air conditioning. It is illegal to vent any refrigerant to the environment during repair, service, maintenance, recycling or disposal of refrigeration and air conditioning equipment because of the harmful effect of these chemicals on our atmosphere. Refrigerants must be processed using one of the following methods:
Additional details are provided below. Refrigerant Recovery. The rules for recovery depend on whether the refrigerant will be sent off-site to a reclamation facility or to a MVAC service center for reuse without prior reclamation. If the refrigerant will be sent off-site to a reclamation facility, then refrigerant must be recovered using equipment that reduces the system pressure to 102 mm (4 inches) of mercury vacuum. There is no restriction on who performs the recovery. That person does not need to be a certified technician. If the refrigerant will be sent to an MVAC service facility for charging or recharging into an MVAC or MVAC-like appliance without prior reclamation, then the same rule applies, but there is a further restriction. Prior to such charging or recharging, the refrigerant must be recovered using approved refrigerant recycling equipment dedicated for use with MVACs and MVAC-like appliances. The recovery process must be performed either by a certified technician, or by an employee, owner, or operator of, or contractor to, the auto recycling facility. Storage of Refrigerant. Store refrigerant in tanks that meet the federal Department of Transportation (DOT) or Underwriters Laboratory (UL) standards. Label tanks according to their contents. Sale of Refrigerant. The rules for sale of refrigerant depend on whether the refrigerant will be sent off-site to a reclamation facility or to a MVAC service center for reuse without prior reclamation. If the refrigerant will be sent off-site to a reclamation facility, then it can be sent to facilities that meet EPA standards for reclaiming refrigerants or those that buy used refrigerant for resale to the reclaiming operations. If the refrigerant will be sent to an MVAC service facility for charging or recharging into an MVAC or MVAC-like appliance without prior reclamation, then it must be sold to a certified technician, who must recycle the used refrigerant before recharging into an MVAC. Recordkeeping and Reporting. The following are recordkeeping and reporting requirements related to recovery, and sale of refrigerant:
Links to the Regulations. Use the following links to view the regulations pertaining to refrigerants. Clean Air Act Sec. 609. Servicing Of Motor Vehicle Air Conditioners EPA's Final Rule Governing Substitutes for CFC-12 Refrigerant in MVACs EPA-Certified Refrigerant Reclaimers When an inspector comes to your facility, there are certain things they check to see if you are in compliance with environmental regulations. It makes good sense for you to perform a "self-audit" and catch and correct problems before they result in penalties. Also, there are some compliance incentives associated with self-audits (see Audit Policy Page). Use the following list to audit your procedures for refrigerant management.
Best Management Practices (BMPs) Most regulations tell you what you have to do to be in compliance, but they don’t explain how to do it. That’s where "best management practices" come into play. BMPs are proven methods that help you to get into compliance and stay there. The following BMPs are recommended for management and recycle of refrigerant:
None.
|
||||||||||||||||||||||||||||||||||||||||||||||||||||||||
